電力中央研究所

報告書「電力中央研究所報告」は当研究所の研究成果を取りまとめた刊行物として、昭和28年より発行されております。 一部の報告書はPDF形式で全文をダウンロードすることができます。

※ PDFのファイルサイズが大きい場合には、ダウンロードに時間がかかる場合がございます。 ダウンロードは1回のクリックで開始しますので、ダウンロードが完了するまで、複数回のクリックはなさらないようご注意願います。

電力中央研究所 報告書(電力中央研究所報告)

報告書データベース 詳細情報


報告書番号

U02007

タイトル(和文)

破砕分級処理によるフライアッシュの混和材としての改質効果

タイトル(英文)

Conversion of fly ash to high-utility product for mineral admixture usage applying crush separation method

概要 (図表や脚注は「報告書全文」に掲載しております)

石炭灰の有効利用を進めるには、フライアッシュをコンクリート用混和材として利用する方法が有効利用策の一つである。フライアッシュの未燃炭素含有量を低く一定水準に保つことができれば、混和材利用量を拡大することができる。本研究では、破砕分級装置を適用した未燃炭素除去灰を混和したモルタルの諸特性の改善効果を評価した。破砕分級処理法の利点は、①処理時にフライアッシュの接触による装置の消耗部品が無いこと、②二枚の回転板を回す僅かなエネルギーを必要とするだけなので、静電分級手法に比べて処理コストが少ないこと、③単位時間あたりの処理量が多いことである。実験室レベルの装置にを適用して改質試験は行なわれ、未燃炭素含有量を低減した改質灰の回収率は、50%~70%であった。回収率は、回転板の回転速度と気流速度に支配される。未燃炭素除去の面では、十分な効果が得られたが、1μm以下の微粒子の回収量を上げるように装置を改良する課題が残された。改質灰を混和したモルタルのフロー値は、原粉を混和した場合の同程度以上であった。AE剤の添加量は、原粉を混和した場合に比べて少なくなり、炭種間による変動も小さくなった。

概要 (英文)

There is a need to gain the utilization amount of fly ash in concrete admixture usage. The utilized amount of fly ash will be gained if the unburned carbon content of fly ash could be stable in low level. In this study, we evaluate the improvement effect on properties of mortar that admixed the decarbonized fly ashes, which were obtained by applying crush separation method. The advantages of this process are: (1) no consumption parts in the processor caused by contact of fly ash, (2) very low processing cost comparing to the electrostatic separation methods because of small energy needed only to keep rotating two plates, (3) high processing volume per hour. Tests were performed by applying Laboratory-scale separator and its recovery rate of low LOI fly ash was about 50-70%. The recovery depends upon the rotating speed of plates and air stream velocity in the separator. There was an enough separating effect, but leaving a room to revise the separator enable to gain small particle size of fly ash in the recovery, i.e., under 1 micro-m. The flow values of mortar with processed low LOI fly ashes were almost the same or better than those with original ashes. The dosage of AE agent was controlled in lower level than the case of original ash usage, and there was no difference in the dosage among processed low LOI fly ashes derived from different types of original ashes.

報告書年度

2002

発行年月

2002/07

報告者

担当氏名所属

山本 武志

我孫子研究所材料構造部

金津 努

我孫子研究所材料構造部

井野場 誠治

我孫子研究所環境科学部

小島定俊

日機装(株) 開発センター

キーワード

和文英文
フライアッシュ fly ash
破砕分級 crush separation
未燃炭素除去 decarbonization
強熱減量 loss on ignition
有効利用 utilization
Copyright (C) Central Research Institute of Electric Power Industry